Henan Yuji Boiler Vessel Manufacturing Co., Ltd.
Adhering to Honesty and Foundry Quality
Add to Cart
Product Discription
LSS Oil Fired Steam Generator
The vertical steam supplied by the LSS receives the structure of the vertical tube. A special protection tube between the two lower rings and the upper and lower protective tubes produces three gases. Zoom in and burn
For radiators and capacitors, the thermal efficiency can be 93% to 100%. Use steam - water separators and external steam. Water distributors provide high quality dry pairs, saving fuel, reducing system size and extending service life.
1. Easy to maintain:
At the bottom, there is an inspection door to inspect and clean the inside of the oven for easy maintenance.
2. Meet the environmental requirements:
Qualitative and reliable burners burn all the fuel, but greatly reduce the emission of hazardous waste. Test results from various departments show that vapor (gas) vapor meets national environmental protection requirements.
3. The amount of evaporation can be increased:
The steam engine can be designed with multiple units (without restrictions) and can be controlled by a computer. You can add shared tasks. Significant parts of steam energy (water purification, pumps, burners, electronic control panels and main valve blocks) have been produced at the factory.
4. The installation is completed:
Can connect water, electricity and steam pipes to the site, saving installation time and effort.
5. Reliable accessories:
Support is provided with vodka, control box, water purifier and valve, national quality pump equipment. The support system provides safe and reliable operation of steam power and improves the quality of the steam power.
Technical Parameters
| Main Technical Reference for Fuel (Gas) Steam Generator | ||||||
| Item Unit | LSS0.05 | LSS0.1 | LSS0.15 | LSS0J2 | ||
| Rated evaporation | Kg/h | 50 | 100 | 150 | 200 | |
| Rated Pressure PTEPREppoPressure | MPa | 0.4/0.7 | ||||
| Rated steam temperature | c | 151/171 | ||||
| Rated feed water temperature | °C | 20 | ||||
| Evaporator efficiency | / | >92% | ||||
| Applicable Fuel | / | Gas light oil | ||||
| Theoretical fuel consumption | Gas | NM3/h | 4 | 8 | 12 | 16 |
| Light Oil | Kg/h | 3.3 | 6.5 | 9.8 | 13 | |
| Gas supply pressure | mbar | 60- 100 | ||||
| water volume | L | <30 | ||||
Note: The fuel consumption in the table is based on the low calorific value of biomass particles 17084 KJ/Kg (4085 Kcal/Kg).Calculations show that if the low calorific value of biomass fuel is higher than that, the corresponding fuel consumption will be more economical than the values in the table.
| Configuration and Interface Size of Fuel (Gas) Steam Generator | ||||||
| Item Unit | LSS0.05 | LSSO.l | LSS0.15 | LSS0.2 | ||
| Outward Size of Main Engine
(length * width * height) | / | mm | 620*620*830 | 690*690*968 | 750*750*1130 | 800*800*1286 |
| Transport Dimension
| / | mm | 206 | 252 | 303 | 350 |
| Mainframe Transport Weight | DN | mm | G 1/2- | Gl' | Gl" | G 1* |
| Main Steam Valve Pipe Diameter | DN | mm | Gl/2" | Gl/2- | Gl/2- | Gl/2° |
| Feed Water Valve | DN | mm | G1 1/4” | G11/4- | G11/4- | G11/4- |
| Safety Valve Diameter | DN | mm | Gf | GF | Gl" | Gl" |
| Drain Valve Pipe Diameter | DN | mm | 133 | 133 | 159 | 159 |
Remarks: We will reserve rights to change the above mentioned data due to continuous policy transformation and product improvement.